Waste Heat Driven Integrated Membrane Distillation for Concentrating Nutrients and Process Water Recovery at a Thermophilic Biogas Plant

Sammanfattning

To efficiently utilize low-concentrate digestate nutrients, further treatment is needed to decrease their volume, recover process water, and increase nutrient concentrations. Membrane distillation (MD) is a thermally driven process that is advantageous due to its ability to harness low-grade waste heat to treat highly complex wastewater streams. This study assessed the techno-economic performance of integrating MD for two-fold concentrations of nutrients and the recovery of process water from digestate at a thermophilic biogas plant. Thermal assessment showed that the recovered waste heat from flue gas and digestate fully met the thermal energy demand of MD and saved 20% of boiler energy by heating incoming slurry. The permeate flux from MD was 3.5 L/(m(2)h) and 3.1 L/(m(2)h) at 66 degrees C and 61 degrees C digestate inlet temperatures during winter and summer, respectively. With internal heat recovery, the specific heat demand for MD was 80 kWh/m(3) and 100 kWh/m(3) in winter and summer, respectively. The unit cost of MD permeate was estimated to be 3.6 euro/m(3) and 4.1 euro/m(3) at a digestate feed temperature of 66 degrees C and 61 degrees C (with heat recovery), and 7.6 euro/m(3) and 9.1 euro/m(3) (without heat recovery) in winter and summer, respectively. However, cost sensitivity analyses showed that waste heat recovery and thermal energy cost variations had a significant impact on the MD permeate production cost. Nevertheless, the economic assessment indicated that the thermal integration of a biogas plant with industrial-scale MD digestate treatment capacity could be economically feasible, with winter being more economically favorable due to higher waste heat recovery.

Nyckelord

thermophilic biogas plant; membrane distillation; digestate effluent treatment; concentrated nutrients and water recovery; techno-economic analysis

Publicerad i

Sustainability
2022, Volym: 14, nummer: 20, artikelnummer: 13535
Utgivare: MDPI

SLU författare

• Nordberg, Åke

  • Institutionen för energi och teknik, Sveriges lantbruksuniversitet
    

Globala målen

SDG6 Rent vatten och sanitet för alla


UKÄ forskningsämne

Bioenergi


Publikationens identifierare

DOI: https://doi.org/10.3390/su142013535

Permanent länk till denna sida (URI)

https://res.slu.se/id/publ/119799